|
||
|
27th June 2016, 07:42 | #1 |
Loves to post
Rover 75 Tourer Join Date: Mar 2009
Location: Bishop Auckland, Co. Durham
Posts: 267
Thanks: 48
Thanked 64 Times in 50 Posts
|
Help Please.... I think I need a new fuel pump!!
Good morning all,
Please help... Doing my usual routine this morning taking kids to school... did my oil/coolant checks (all ok), got in car MG ZTT (1.8T), turned key car fired up briefly then died (ie, just stopped).... have tried starting again, after leaving it (while took kids to school in wife's car)... turns over but doesn't fire, which has got me thinking it could be the fuel pump??? anybody got any ideas.... If it is fuel pump? anybody know where I can get one at short notice around liverpool/manchester area... does Mat (DMGRS) stock them? also is there a thread or "how to" for replacement. Any help would most appreciated.... Cheers Maurice |
27th June 2016, 08:00 | #2 |
Loves to post
Rover 75 Tourer Join Date: Mar 2009
Location: Bishop Auckland, Co. Durham
Posts: 267
Thanks: 48
Thanked 64 Times in 50 Posts
|
.... Just been reading up on this for more info.... could it be the filter housing coming apart??? ie need an orange clip.... if so, where would I get one?
Cheers Maurice |
27th June 2016, 08:05 | #3 |
This is my second home
Rover 75 saloon x2, Rover 75 Tourer x2, Rover 220 Coupe Turbo Join Date: Aug 2010
Location: Kirkcaldy, Fife
Posts: 9,036
Thanks: 2,278
Thanked 2,852 Times in 1,718 Posts
|
Did you get the inertia switch message on your display?
__________________
Wanted - Indian bride. Cash waiting. (All sorted - bargain) First name and forum name: Ravinder Rover 75 2.0 CDT Connoisseur SE 116 (160 remap) Royal Blue (JFM) This vehicle was the 50,481st 75 to run off the production line, out of 112,381 This vehicle was the 2,238th 75 CDT Connoisseur SE to be made out of 3,775 This vehicle was the 5,002nd 75 in Royal Blue (code: JFM) to be made out of 14,420 Royal Blue 75s |
27th June 2016, 08:19 | #4 |
Loves to post
Rover 75 Tourer Join Date: Mar 2009
Location: Bishop Auckland, Co. Durham
Posts: 267
Thanks: 48
Thanked 64 Times in 50 Posts
|
Hi Ravinder,
No I don't think so.... What does it look like? Sent from my SM-N9005 using Tapatalk |
27th June 2016, 08:27 | #5 |
This is my second home
Hyundai i10 998cc Join Date: Mar 2012
Location: Kilmarnock
Posts: 6,602
Thanks: 2,088
Thanked 2,298 Times in 1,349 Posts
|
Hi.
Could well be filter separation, also could be the pump fuse or relay. Try and get an assistant, get him to switch on the ignition while you listen at the filler cap, you should hear the pump for a few seconds, if it runs at least you can discount the pump, relay and fuse, making the filter problem most likely. Cam sensors can fail but usually not in the way you describe. Can you check the error codes?
__________________
Cheers from Trevor MM0KJJ |
27th June 2016, 09:44 | #6 |
Loves to post
Rover 75 Tourer Join Date: Mar 2009
Location: Bishop Auckland, Co. Durham
Posts: 267
Thanks: 48
Thanked 64 Times in 50 Posts
|
Hi Trevor,
Thanks for your reply.... It isn't the fuel pump (although I did replace the fuse as it had 30A not 20A??? as stated in Haynes Manual.... can hear the pump when turn key. Checked the filter too.... don't think it is that either as the seal between the two parts (Top & housing) appears good... not loose, appears to be a good tight fit. I guess it must something up the front end then... any ideas??? Battery on charge now as had drained a bit. Cheers Maurice |
27th June 2016, 09:45 | #7 |
This is my second home
Rover75 and Mreg Corsa. Join Date: Nov 2006
Location: Sumweer onat mote o'dust (Sagin)
Posts: 21,751
Thanks: 341
Thanked 3,660 Times in 2,924 Posts
|
A point to remember about FFS is that continual attempts to start the engine will result in the fuel being transferred to the LHS of the tank. It will do this until the pump as nothing left to err, pump. When that happens, apart from fitting the orange clip, you'll need more petrol putting into the tank.
Your description certainly has the characteristics of Fuel Filter Syndrome so a venture into the tank is on the cards. You'll be wise to fit the clip whatever the cause turns out to be, so get one ordered. There are HowTos on lifting the rear seat cushion to gain access to the tank port as well as fitting the clip and returning the filter unit to the tank. This last step in itself is a common cause of trouble, so ensure you have familiarised yourself with every step before diving in. TC |
27th June 2016, 09:48 | #8 |
Loves to post
Rover 75 Tourer Join Date: Mar 2009
Location: Bishop Auckland, Co. Durham
Posts: 267
Thanks: 48
Thanked 64 Times in 50 Posts
|
Cheers TC,
Do you know where I can get the orange clips from? Cheers Maurice |
27th June 2016, 09:56 | #9 |
This is my second home
Rover75 and Mreg Corsa. Join Date: Nov 2006
Location: Sumweer onat mote o'dust (Sagin)
Posts: 21,751
Thanks: 341
Thanked 3,660 Times in 2,924 Posts
|
I see Rimmer are saying WJC000230 is NLA http://www.rimmerbros.co.uk/Item--i-WJC000230
but Endon Services are still listing them. http://www.allcarpartsfast.co.uk/sea...000230&x=0&y=0 Worth asking and do a Google search on the part number, which usually come up with something. TC |
27th June 2016, 09:58 | #10 |
This is my second home
Hyundai i10 998cc Join Date: Mar 2012
Location: Kilmarnock
Posts: 6,602
Thanks: 2,088
Thanked 2,298 Times in 1,349 Posts
|
Hi.
From Rimmer brothers I believe. My car is the original set up which has a different filter and doesn't suffer with this problem. Cam sensor is a possible as is the crank sensor, a T4 session may be called for if it's not the filter. T-cut beat me to it. Marinabrian has used a self tapper in the past.
__________________
Cheers from Trevor MM0KJJ Last edited by murphyv310; 27th June 2016 at 10:01.. |
Thread Tools | |
Display Modes | |
|
|