|
||
|
24th November 2006, 14:46 | #1 |
Regular poster
none Join Date: Nov 2006
Location: none
Posts: 93
Thanks: 0
Thanked 0 Times in 0 Posts
|
Battery Drain info
Battery drain current logged using a DC digital clamp meter, not the most accurate but should be within about +-5%
The measurements were taken on the battery main earth lead. 2004, R75 CDTi ConnSE. Sat Nav, Parrot Bluetooth, Icelink Plus Original Battery. Measurements.... Ignition off, car locked up, 4.7 Amp, after sat nav shut down drops to 2.5 Amp, 15 minutes later still same reading 0.57 Amp after 60 minutes The next test will be to check the drain when the car has been left overnight. Next morning tests... 0.48 Amp .... note this is too high ! Looks like it is being caused by I-Bus activity ! Icelink Interface was not operating correctly, the tag names were not displayed on the TV screen. PBs 1-5 & 6 had no effect on the I-Pod, looks like the interface had locked up repeatedly sending data on the IBus Interface reset by disconnection. Drain current after 16 Minutes... 88mA .... this is still a bit high, would expect 30mA or less, but from what I could see searching the Web this is about normal. Rave manual gives no data on this drain current. Update, 3 Nov 06 New MKIV BMW nav fitted 2 Nov 06 Drain current now 66mA after 16 minutes. .... Looks like BCU shuts systems down if no IBus/Kbus activity. Ignition off car unlocked 4.7 Amp, drops after a few minutes to 4.3 Amps .... Turning Ignition off, Sat powered down after 1min 20 Secs Key on 1st position 4.3 Amp, no interior lights on, radio not on, screen display on The readings are not stable, flicking between 4 and 5 Amps, average about 4.3 Amps. radio or TV switched on, little or no difference to above current drain. 4 Amps when Screen switched off Little or no difference when Icelink Plus or Parrot Bluetooth disconnected. Ignition on 2nd position, engine not running 22 Amps with both fuel pumps running... both pumps confirmed as running by listening to them. 9.1 Amps when pumps stop, also seen it dropping to about 6.5 Amps, no idea why. 72 Amps with glowplugs on drops to 22 Amps when glowplugs turn off Cooling Fan, tested on Ign 2, engine not running, fuel pumps stopped, meter zeroed before fan started. 18.5 Amp Low fan speed ....easy to test with the PIC system installed 22.2 Amp Med fan speed 27.7 Amp High fan speed Battery volts 12.59 V Before fan tests. 12.09 V After fan tests. Engine started on idle Battery 14.34 V Charge Rate 35 Amps .... High charge rate caused by the Cooling fan tests carried out without engine running. After 10 Mile run At idle 14.35 Volts Charge Rate 3 Amps Let me know what other drain info would be useful and I will measure and update the thread. Maybe Under bonnet fuel pump & tank fuel pump ? |
|
|