2.0 CDT Smoke on start up and misfire - injector woes?
Deleted post
|
Will most likely be 1 injector playing up, a T4 session should show which one
|
If you haven't done so already, a bottle of decent injector cleaner may help - Forte comes well recommended.
|
Quote:
|
Sorted a leaky injector today, after doing a leak back test.
https://i.imgur.com/OEqhvtNl.jpg1 https://i.imgur.com/n3TGJMKl.jpg2 Very obvious which one during the test it filled up within 10 seconds the other three did not even get inch up the tube, let alone any in the bottle. https://i.imgur.com/IEWTV1Zl.jpg3 https://i.imgur.com/nbuDrNZl.jpg4 |
2.0 CDT Smoke on start up and misfire - injector woes?
Deleted post
|
Is your PCV filter ok?
|
2.0 CDT Smoke on start up and misfire - injector woes?
Deleted post
|
[QUOTE]
Quote:
Crankcase breather is just in front and a little under the air filter, remove the main engine cover. https://i.imgur.com/wrvsTHpl.jpg1 Then remove the air duct. https://i.imgur.com/gJPVYhxl.jpg2 Next remove the air filter cover, allen key start with the rear corner OS. https://i.imgur.com/WmlCWQ5l.jpg3 Then near side corner. https://i.imgur.com/egLGOGFl.jpg4 https://i.imgur.com/Fvz5hmbl.jpg5 Three along the top. https://i.imgur.com/yRORSdIl.jpg6 Lift it free. https://i.imgur.com/WO9225Gl.jpg7 Now remove the three torx holding the injector wiring, a 5mm socket works on these, this car had posi screws. https://i.imgur.com/i7G7rP8l.jpg8 Open the clips on the ends, and pull of the plugs. https://i.imgur.com/AxeXpWNl.jpg9 Lift wiring out of the way. https://i.imgur.com/wPul3Qpl.jpg10 You can now tackle the PCV filter again allen key. https://i.imgur.com/ChnIyaBl.jpg11 Some just lift out others you have to remove the leak back hose from the injectors, first pull off the spring clips. https://i.imgur.com/cJR4DYvl.jpg12 https://i.imgur.com/pZq3S2Yl.jpg13 Do three, then tease up the T joints or use some pliers and pull upwards. https://i.imgur.com/NQMdlqPl.jpg14 Now lift the PCV out with the filter in one. https://i.imgur.com/cHjVNPHl.jpg15 Change it for a new filter, i already had one made up with a spare case. https://i.imgur.com/HCcLfgdl.jpg16 Before refitting change out the seals. https://i.imgur.com/OpK3ccXl.jpg17 https://i.imgur.com/d8gXNKRl.jpg18 Fit new filter replace all you removed in reverse. https://i.imgur.com/ziU0Okxl.jpg19 Hopefully it's not as bad as this one was, cheers Arctic. |
2.0 CDT Smoke on start up and misfire - injector woes?
Deleted post
|
All times are GMT. The time now is 06:54. |
Powered by vBulletin® Version 3.8.11
Copyright ©2000 - 2024, vBulletin Solutions Inc.
Copyright © 2006-2023, The Rover 75 & MG ZT Owners Club Ltd